Since '02 xBhp is different things to different people. From a close knit national community of bikers to India's only motorcycling lifestyle magazine and a place to make like-minded biker friends. Join us

Axor
Magazine
Castrol Power 1

Hot days = molten tar = slip/slide.

Our Partner

Announcement

Collapse
No announcement yet.

Honda CB Trigger sound issue

Collapse
X
Collapse
 
  • Page of 1
  • Filter
  • Time
  • Show
Clear All
new posts
Previous template Next
  • Spiritsagar
    replied
    Re: Honda CB Trigger sound issue

    Originally posted by vivek33 View Post
    No, I haven't checked it yet. Looking for some good mechanic.
    Hi i too faced the exact same issue, than i let my mechanic open the engine, it was because of the shaft bearing. That torn out, wobbling a little, and its combined effect with all the gears making sound when you tried to pull throttle holding the clutch at lower speeds.

    Leave a comment:

  • vivek33
    replied
    Re: Honda CB Trigger sound issue

    Originally posted by psr View Post
    Get your bike checked with ASC. local mech sometimes do not have the experience..Did you check the GB sprocket slack ?ie., the small sprocket fixing on the drive shaft ?
    No, I haven't checked it yet. Looking for some good mechanic.

    Leave a comment:

  • psr
    replied
    Re: Honda CB Trigger sound issue

    Originally posted by vivek33 View Post
    Hi @psr sir,

    Is there any way of diagnosing it correctly without replacing any non-essential part which is not at all worn out. Because many of the machanic guys here in my area diagnosed it wrongly. They have been doing it like trial & error and made me to replace non-essential parts like chain sprocket, clutch plates, piston, removing the play in clutch housing, etc which were not at all required to be replaced. It almost costed of around Rs. 10000 and now I am afraid of giving it a try again

    Please suggest!!

    Thanks.
    Get your bike checked with ASC. local mech sometimes do not have the experience..Did you check the GB sprocket slack ?ie., the small sprocket fixing on the drive shaft ?

    Leave a comment:

  • vivek33
    replied
    Re: Honda CB Trigger sound issue

    Originally posted by psr View Post
    Then you have to open the engine and check..it can be a simple or complicated problem which will be known only on opening the engine....
    Have you checked if the (GB) small sprocket is bolted on to the drive shaft TIGHTLY, and has NO PLAY ? this can also give same symptom and noise...so check the easy ones first before going for engine diagnosis..
    Good Luck
    Hi [MENTION=32286]psr[/MENTION] sir,

    Is there any way of diagnosing it correctly without replacing any non-essential part which is not at all worn out. Because many of the machanic guys here in my area diagnosed it wrongly. They have been doing it like trial & error and made me to replace non-essential parts like chain sprocket, clutch plates, piston, removing the play in clutch housing, etc which were not at all required to be replaced. It almost costed of around Rs. 10000 and now I am afraid of giving it a try again

    Please suggest!!

    Thanks.

    Leave a comment:

  • psr
    replied
    Re: Honda CB Trigger sound issue

    Originally posted by vivek33 View Post
    Hi @psr sir,

    Thanks for your reply.

    The sound seems to be coming from gearbox side, because when the "khad khad khad" sound comes I can feel some little bit of vibration at gear shifting lever.

    So still can it be a problem at clutch plate side?
    Then you have to open the engine and check..it can be a simple or complicated problem which will be known only on opening the engine....
    Have you checked if the (GB) small sprocket is bolted on to the drive shaft TIGHTLY, and has NO PLAY ? this can also give same symptom and noise...so check the easy ones first before going for engine diagnosis..
    Good Luck

    Leave a comment:

  • vivek33
    replied
    Re: Honda CB Trigger sound issue

    Originally posted by psr View Post
    Always do RPM matched shifting into appropriate gearing for best FE and performance..Since You have the bike for more than 4 years and only now had faced this particular problem, it is possible that some parts have been worn out..

    If as you say the sound is from the clutch side, then check for clutch bell to clutch plates play..The clutch bell has notches in which the stationery plates stay..if these notches have become worn and allows plate lips to move by more than 2mm then clutch bell needs replacement.

    2. Check for clutch bell bearing wear..

    Good luck.
    Hi @psr sir,

    Thanks for your reply.

    The sound seems to be coming from gearbox side, because when the "khad khad khad" sound comes I can feel some little bit of vibration at gear shifting lever.

    So still can it be a problem at clutch plate side?

    Leave a comment:

  • psr
    replied
    Re: Honda CB Trigger sound issue

    Originally posted by vivek33 View Post
    Hi Samarth,

    Thanks for taking time and replying my thread.

    I am also aware of the fact that riding the bike with half clutch pressed in bad. But in the heavy traffic we have to ride our bike like this, no option for that.
    Always do RPM matched shifting into appropriate gearing for best FE and performance..Since You have the bike for more than 4 years and only now had faced this particular problem, it is possible that some parts have been worn out..

    If as you say the sound is from the clutch side, then check for clutch bell to clutch plates play..The clutch bell has notches in which the stationery plates stay..if these notches have become worn and allows plate lips to move by more than 2mm then clutch bell needs replacement.

    2. Check for clutch bell bearing wear..

    Good luck.

    Leave a comment:

  • vivek33
    replied
    Re: Honda CB Trigger sound issue

    Originally posted by Samarth 619 View Post
    Topic Approved.

    Please note that riding the bike with clutch half pressed, is called "riding the clutch" and its a very bad habit. It causes only damage and no good, even if performance seems increased for a while..

    If you can't maintain a particular speed, lower a gear and ride without disengaging clutch as far as possible.


    @psr Dear sir, could you please help the member? The problem seems to be a common one.
    Hi Samarth,

    Thanks for taking time and replying my thread.

    I am also aware of the fact that riding the bike with half clutch pressed in bad. But in the heavy traffic we have to ride our bike like this, no option for that.

    Leave a comment:

  • Samarth 619
    replied
    Re: Honda CB Trigger sound issue

    Topic Approved.

    Please note that riding the bike with clutch half pressed, is called "riding the clutch" and its a very bad habit. It causes only damage and no good, even if performance seems increased for a while..

    If you can't maintain a particular speed, lower a gear and ride without disengaging clutch as far as possible.


    @psr Dear sir, could you please help the member? The problem seems to be a common one.

    Leave a comment:

  • vivek33
    started a topic Honda CB Trigger sound issue

    Honda CB Trigger sound issue

    Hi,

    I have a Honda CB Trigger (150 CC) bike. I have bought it 4.5 years ago and its total running is 32000 km as of now.

    In October 2017 while doing its servicing I had replaced its clutch plates because bike's pickup wasn't good and mechanic told me to change it.

    Then after 2 months some strange noise has started coming from the engine or gearbox side. The noise comes when in the heavy traffic the bike is in slow speed (15-20 km/hr) and half clutch lever is pressed and little bit accelerating of throttle. The noise is like "khad khad khad khad".

    To resolve this issue I have visited many mechanics and as of now I have replaced my chain sprocket, clutch plates (again), piston. I have spent almost Rs. 10000 for this issue but this issue is still there.

    Some please help me to find out the exact cause and the solution.

    Thanks.
    Tags: clutch plate, gearbox problem, honda bikes, honda trigger
Previous template Next
Working...
X
© xBhp.com 2026. All rights reserved.
Designed by xBhp